Random Starting problems- 2002 Xterra
-
- Newbie
- Posts: 17
- Joined: Tue Jun 10, 2008 7:16 pm
- Reactions score: 0
- Location: Calgary
- Make/Model: Xterra
- Year: 2002
- Tim's: on diet by order of SWMBO
- Contact:
Random Starting problems- 2002 Xterra
Hi all
Some may remember me- I’m the guy from out west that keeps an Xterra as a summer vehicle at our Rideau lakes cottage. I change the oil before winter after 3,000 -5,000 km of summer driving and then X becomes a garage queen for the winter. After 13 years, it now has 160kkm and has been completely reliable except for 3 random starting issues in the last year. The last one was this morning.
I get in to start the car and get one ‘click’ (starter solenoid?) when I turn the key, but no turning of the starter. There is no indication that the problem is about to happen. This morning, the truck had worked fine and the engine was still warm. Last time it happened, the motor was cold.
- Dash lights, radio and headlights work no problem and at the usual brightness
- battery is one year old
- I’ve sanded clean the battery posts, connectors and engine ground
- strangely , twice when this has happened, it started with a boost. Yet the battery shows no sign of being weak. If the problem is like before, it’ll keep starting fine with no jump until it randomly stops working again... which could be weeks from now.
lazy starter/ solenoid? Maybe it’s not related, but the truck works fine in the summer but this problem has always happened in the ‘ colder’ weather
Any suggestions? Thanks in advance
Some may remember me- I’m the guy from out west that keeps an Xterra as a summer vehicle at our Rideau lakes cottage. I change the oil before winter after 3,000 -5,000 km of summer driving and then X becomes a garage queen for the winter. After 13 years, it now has 160kkm and has been completely reliable except for 3 random starting issues in the last year. The last one was this morning.
I get in to start the car and get one ‘click’ (starter solenoid?) when I turn the key, but no turning of the starter. There is no indication that the problem is about to happen. This morning, the truck had worked fine and the engine was still warm. Last time it happened, the motor was cold.
- Dash lights, radio and headlights work no problem and at the usual brightness
- battery is one year old
- I’ve sanded clean the battery posts, connectors and engine ground
- strangely , twice when this has happened, it started with a boost. Yet the battery shows no sign of being weak. If the problem is like before, it’ll keep starting fine with no jump until it randomly stops working again... which could be weeks from now.
lazy starter/ solenoid? Maybe it’s not related, but the truck works fine in the summer but this problem has always happened in the ‘ colder’ weather
Any suggestions? Thanks in advance
- Bow_Tied
- Moderator
- Posts: 6160
- Joined: Mon Jun 02, 2008 11:20 pm
- Reactions score: 4
- Location: London
- Make/Model: Xterra P4X ZR2 Bison
- Year: '15/20
- Tim's: Medium DD
Re: Random Starting problems- 2002 Xterra
The clicking very much sounds like a solenoid issue. I had a car that did this once whenever it was hot - odd to me you'd only notice when cold. I would check all the electrical connections at the starter itself. A load test on the battery might also be worthwhile. If you suspect any previous owner has done any wiring repairs in the area of the starter double check that work.
I suppose it could also be a dead spot in the starter itself.
I suppose it could also be a dead spot in the starter itself.
#MoreRon
"Most of the members are people, but there are a few exceptions." - Miner
"Most of the members are people, but there are a few exceptions." - Miner
- Morpheus
- Moderator
- Posts: 4318
- Joined: Wed Apr 09, 2008 8:42 am
- Reactions score: 0
- Location: Cambridge
- Make/Model: Xterra
- Year: 2003
- Tim's: 3x3
- Contact:
Re: Random Starting problems- 2002 Xterra
x2 for dead spot in the starter. Mine does that sometimes too.
-
- Newbie
- Posts: 17
- Joined: Tue Jun 10, 2008 7:16 pm
- Reactions score: 0
- Location: Calgary
- Make/Model: Xterra
- Year: 2002
- Tim's: on diet by order of SWMBO
- Contact:
Re: Random Starting problems- 2002 Xterra
Thanks for the info..
I did check the battery voltage, charging current and charging voltage- all ok. so it does seem to be a starter issue. The dead spot certainly explains the randomness... but I’ll clean the wires and connectors when I replace the starter next year.
And in other (I think) unrelated news, I replaced the blower resistor pack this week as the fan just started acting up.
This has been a very reliable vehicle . In 13 years and 40k km of ownership, I’ve replaced one set of tires, two batteries, front pads and rotors, timing belt and water pump , an A/C hose, a blower resistor pack, and 13 oil changes . Oh... and one bearing repack. That’s probably around $2000 total over 13 years with me doing everything except tires and A/C.
If only the poor gas mileage was caused by amazing acceleration, it’d be perfect!![Approval Happy :-)](./images/smilies/icon_e_biggrin.gif)
I did check the battery voltage, charging current and charging voltage- all ok. so it does seem to be a starter issue. The dead spot certainly explains the randomness... but I’ll clean the wires and connectors when I replace the starter next year.
And in other (I think) unrelated news, I replaced the blower resistor pack this week as the fan just started acting up.
This has been a very reliable vehicle . In 13 years and 40k km of ownership, I’ve replaced one set of tires, two batteries, front pads and rotors, timing belt and water pump , an A/C hose, a blower resistor pack, and 13 oil changes . Oh... and one bearing repack. That’s probably around $2000 total over 13 years with me doing everything except tires and A/C.
If only the poor gas mileage was caused by amazing acceleration, it’d be perfect!
![Approval Happy :-)](./images/smilies/icon_e_biggrin.gif)
-
- Newbie
- Posts: 17
- Joined: Tue Jun 10, 2008 7:16 pm
- Reactions score: 0
- Location: Calgary
- Make/Model: Xterra
- Year: 2002
- Tim's: on diet by order of SWMBO
- Contact:
Re: Random Starting problems- 2002 Xterra
Ok... change in plan.
My nephew wants to borrow the truck until Christmas. I haven’t got time to fix it before I give it to him as we leave on Monday
Any recommendations for mechanics in Ottawa?
My nephew wants to borrow the truck until Christmas. I haven’t got time to fix it before I give it to him as we leave on Monday
Any recommendations for mechanics in Ottawa?
- Adam
- Moderator
- Posts: 2962
- Joined: Wed Jul 30, 2008 4:10 pm
- Reactions score: 3
- Location: Ottawa Ontario
- Make/Model: Xterra SE SC
- Year: 2002
- Tim's: Medium Regular
Re: Random Starting problems- 2002 Xterra
Takaki automotive is who I send people to.
![Image](https://i.imgur.com/fLG5S7n.jpeg)
There is more stupidity than hydrogen in the universe, and it has a longer shelf life. -Frank Zappa
-
- Newbie
- Posts: 17
- Joined: Tue Jun 10, 2008 7:16 pm
- Reactions score: 0
- Location: Calgary
- Make/Model: Xterra
- Year: 2002
- Tim's: on diet by order of SWMBO
- Contact:
- Adam
- Moderator
- Posts: 2962
- Joined: Wed Jul 30, 2008 4:10 pm
- Reactions score: 3
- Location: Ottawa Ontario
- Make/Model: Xterra SE SC
- Year: 2002
- Tim's: Medium Regular
Re: Random Starting problems- 2002 Xterra
No problem. Let us know how it goes. I just sent my uncle there with their rav4. Saved them over $1500 that the Toyota dealer wanted to charge! I also love their funky building.
![Image](https://i.imgur.com/fLG5S7n.jpeg)
There is more stupidity than hydrogen in the universe, and it has a longer shelf life. -Frank Zappa
-
- Premium Member
- Posts: 2893
- Joined: Sun Nov 23, 2008 9:55 am
- Reactions score: 2
- Location: london
- Make/Model: Jeep JKUR
- Year: 2013
- Tim's: Med 2 milks 1 sugar
Re: Random Starting problems- 2002 Xterra
Post picture of funky building.
Sent from my iPhone using Tapatalk
Sent from my iPhone using Tapatalk
-
- Newbie
- Posts: 17
- Joined: Tue Jun 10, 2008 7:16 pm
- Reactions score: 0
- Location: Calgary
- Make/Model: Xterra
- Year: 2002
- Tim's: on diet by order of SWMBO
- Contact:
Re: Random Starting problems- 2002 Xterra
Of course, my random starting problem randomly did not cause a single problem while they had it. Decided to replace the starter anyway, and hasn’t been a problem since.Adam wrote:No problem. Let us know how it goes.
Perhaps we fixed it?
And it is quite an eclectic garage. I particularly liked that the service advisor spent about 10 minutes asking about the problem, symptoms, and what I’ve done so far. Most just want to know it’s a starting problem and they figure it out from there.
Thanks again for the recommendation